Product ID:METALCLAD SPEEDALLOY ACTIVATOR
MSDS Date:09/01/1992
FSC:8010
NIIN:00N036977
Kit Part:Y
MSDS Number: BQTPT

PALMER INTERNATIONAL INC

WORCESTER, PA 19490
US

Emergency Phone: 215-584-4241

Info Phone: 215-584-4241

Cage: 00933

PALMER INTERNATIONAL, INC.

WORCESTER, PA 19490 US

Telephone: 610-584-4241

Cage: 00933

0.1

Fraction By Weight: 40%

SILICA GEL

CAS: 112945-52-5

RTECS: VV7310000

Fraction By Weight: 54%

OSHA PEL 6 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

SILICON DIOXIDE (AMORPHOUS)

CAS: 67762-90-7

Fraction By Weight: 2%

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE:CAN CAUSE IRRITATION. MAY CAUSE
CHEMICAL BURN. SKIN:PROLONGED OR REPEATED CONTACT CAN CAUSE
MODERATE IRRITATION, DERMATITIS. INHAL:CAN CAUSE RESPIRATORY
IRRITATION. INGEST:SLIGHTLY TOXIC.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYE:FLUSH W/LRG AMTS OF WATER LIFTING EYELIDS OCCASIONALLY;
GET MD. SKIN:WASH THORO W/SOAP & WATER, REMOVE CONTAM CLTHG IMMED &
WASH BEFORE REUSE. INGEST:DO NOT INDUCE VOMIT. KEEP PERSON WARM,
QUIET & GET MD. ASPIR OF MATL INTO LUNGS DUE TO VOMIT CAN CAUSE
CHEM PNEUMIT WHICH CAN BE FATAL. INHAL:MOVE TO FRESH AIR. IF BRTHG
DFCLT, GIVE O*2. IF BRTHG STOPPED, GIVE ARTF RESP. KEEP WARM/QUIET
& GET MD.

Flash Point Method:TCC
Flash Point:>200F,>93C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG. USE
WATER FOR COOLING MATERIAL STORED IN VICINITY OF FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.

Spill Release Procedures:SMALL/LARGE SPILL:SCRAPE UP/SOAK UP WITH
ABSORBENT MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:EXPOSURE TO AIR WILL CAUSE SKINNING
AND RENDER MATERIAL UNFIT FOR USE.
Other Precautions:NONE.

Respiratory Protection:IF TLV OF PROD EXCEEDED, A NOISH/MSHA APPROVED
AIR SUPPLY RESPIRATOR IS ADVISED IN ABSENCE OF PROPER ENVIRONMENTAL
CONTROL. OSHA REGS ALSO PERMIT OTHER NIOSH/MSHA APPRVD RESPS.
ENGINEERING/ADMIN CNTRL S SHOULD BE IMPLEMENTED TO REDUCE EXPOS.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Protective Gloves:NITRILE RUBBER GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EYE WASH AND SAFETY SHOWER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.

Vapor Density:HVR/AIR
Spec Gravity:1.63
Evaporation Rate & Reference:O (N-BUTYL ACETATE=1)
Appearance and Odor:CREAM COLOR PASTE; DISAGREEABLE ODOR
Percent Volatiles by Volume:0

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZERS & ACIDS.
Stability Condition to Avoid:KEEP AWAY FROM HEAT AND OPEN FLAME.
Hazardous Decomposition Products:MAY FORM CARBON MONOXIDE AND DIOXIDE;
OXIDES OF NITROGEN.

Waste Disposal Methods:SMALL/LARGE SPILL:INCINERATE OR LANDFILL IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.